山东山汽工程机械(集团)有限公司
热线电话:400-879-1999 山汽微信
郑重声明 购机 售后
在线询价
热线电话:400-879-1999
您现在所在的位置: 首页> 新闻资讯 > 行业新闻

如何保证混凝土搅拌车的规范作业?

所属分类:行业新闻 发布时间:2020-09-03 来源:http://www.shanqijituan.com 浏览量:0

  混凝土搅拌车是我公司主营产品之一,其广泛的应用收到客户的青睐。下面小编带您了解下去如何保证混凝土搅拌车的规范运作:
  Concrete mixer is one of the main products of our company, and its wide application has been favored by customers. Let's take you to know how to ensure the standard operation of concrete mixer truck:
  1.每次使用混凝土搅拌车前,要检查空压车的自保装置是否可靠;还要检查搅拌车叶片的连接螺栓是否牢固;检查各电气装置是否规范可靠,各限位开关是否灵活可靠;检查润滑点急减速是否有足够的润滑油。
  1. Before using the concrete mixer truck, check whether the self-protection device of the air compressor truck is reliable; check whether the connecting bolts of the mixer blade are firm; check whether the electrical devices are standard and reliable; whether the limit switches are flexible and reliable; check whether there is enough lubricating oil for the rapid deceleration of lubricating points.
  2.每次使用之后,都应该将混凝土搅拌车的主车内外、料门上的积料清理并冲洗干净;各个润滑点应加注润滑油,尤其是在轴端的密封处万不可遗漏;冬季应该放尽水路内的液体,放尽空压车贮气筒内的积水和气体;停车后,所有的开关都要处于非工作状态并切断电源。
  2. After each use, the accumulated materials inside and outside the main truck and on the material door of the concrete mixer truck should be cleaned and washed; all lubricating points should be filled with lubricating oil, especially at the sealing part of the shaft end; in winter, the liquid in the water channel should be drained, and the water and gas in the air storage cylinder of the air compressor should be exhausted; after stopping, all switches should be in non working state and cut off Power Supply.
             全自动上料搅拌车
  3.每周还要对设备尽心例行保养。保养的内容为:检查搅拌罐内残留砼的凝结情况,如有凝结应停车进行铲除(注意应切断电源专人看护),检查搅拌叶片与衬板间隙,如不适合进行调整;检查气路系统是否漏气,气缸动作是否可靠;检查减速箱内的润滑油的质量和液面高度,必要时加注或更换;检查供水系统中吸水底阀是否可靠;检查各电器元件是否有损坏现象,必要时修理或更换,检查各接线是否松动;拧开放淤塞,检查轴端密封情况,无异常后再拧入放淤塞。
  3. The equipment should be maintained every week. The maintenance contents are as follows: check the condensation of residual concrete in the mixing tank; if there is condensation, stop the machine to remove it (pay attention to cut off the power supply and take care of special personnel); check the clearance between the mixing blade and the lining plate, and adjust if it is not suitable; check whether the air passage system leaks and whether the cylinder action is reliable; check the quality and level of lubricating oil in the reducer box, and add or replace it if necessary; Check whether the suction bottom valve in the water supply system is reliable; check whether the electrical components are damaged, repair or replace if necessary, and check whether the wiring is loose; open the blockage, check the sealing condition of the shaft end, and screw in and drain the blockage after there is no abnormality.
  4.每隔一个月,还要进行检查保养。月例检查的范围包括:检查螺旋输送车内是否有结块和杂物,如有则;检查皮带的张紧情况,并作适当的调整;检查叶片,衬板的磨损情况;检查上、下车架、料仓、大斜皮带车等部件的连接螺栓是否牢靠,地基是否下沉。
  4. Check and maintain every other month. The scope of monthly inspection includes: check whether there are caking and sundries in the screw conveyor, and remove them if they are; check the tension of the belt and make appropriate adjustment; check the wear of the blades and lining plates; check whether the connecting bolts of the upper and lower frame, silo, large inclined belt car are firm, and whether the foundation is sinking.
  除了这些例行检查以外,每年还要对运行工作的混凝土搅拌车或混凝土搅拌车进行全方面的检查,检查中如果发现问题要及时维修,有的车器零部件若损坏要及时更换以保证设备的正常运行。
  In addition to these routine inspections, all aspects of the running concrete mixer truck or concrete mixer truck should be inspected every year. If problems are found during the inspection, timely maintenance should be carried out. If some parts of the vehicle are damaged, they should be replaced in time to ensure the normal operation of the equipment.
  以上是如何保证混凝土搅拌车的规范运作。相信大家对混凝土搅拌车都有了解。
  The above is how to ensure the standard operation of concrete mixer truck. I believe that everyone has an understanding of the concrete mixer.

 

首页 产品 电话 置顶